Product ID:PM 6003
MSDS Date:04/18/1994
FSC:8030
NIIN:01-226-0240
MSDS Number: CCQVD

PALMER INTERNATIONAL, INC

ROUTE 73 & 363
WORCESTER, PA 19490
US

Emergency Phone: 215-584-4241

Info Phone: 215-584-4241

Cage: 00933

PALMER INTERNATIONAL, INC.

WORCESTER, PA 19490 US

Telephone: 610-584-4241

Cage: 00933

EPOXY RESIN

CAS: 25068-38-6

RTECS: KC2100000

Fraction By Weight: 50-75%

OSHA PEL N/K

ACGIH TLV: N/K

TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC) (MAY

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 20-50%

OSHA PEL 20 MPPCF Z-3

ACGIH TLV: 2 MG/M3 RDUST

DOLOMITE

CAS: 16389-88-1

OSHA PEL N/K

ACGIH TLV: N/K

INORGANIC CHLORITE; (CHLORITE)

CAS: 1318-59-8

OSHA PEL N/K

ACGIH TLV: N/K

CALCITE

CAS: 13397-26-7

OSHA PEL N/K

ACGIH TLV: N/K

MAGNESITE

CAS: 546-93-0

RTECS: OM2470000

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

SILICA, CRYSTALLINE - QUARTZ; (QUARTZ)

CAS: 14808-60-7

RTECS: VV7330000

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 0.1 MG/M3 RDUST

PERLITE; (SODIUM POTASSIUM ALUMINUM SILICATE)

CAS: 93763-70-3

RTECS: SD5254000

Fraction By Weight: 5-20%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

PHTHALIC ACID, DIBUTYL ESTER; (DI-N-BUTYLPHTHALATE) (SARA

CAS: 84-74-2

RTECS: TI0875000

Fraction By Weight: 5-20%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

NONE

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES:CAN CAUSE IRRITATION.
SKIN:PROLONGED OR REPEATED CONTACT CAN CAUSE MODERATE IRRITATION,
DERMATITIS. INHALATION:NORMALLY NO PROBLEM UNLESS HEATED.
INGESTION:SLIGHTLY TOXIC.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
MONOGRAPHS, SUPP, VOL 7, PG 341, 1987:GROUP 2A. NTP 7TH ANNUAL RPT
ON CARCINS. (SUPDAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES:FLUSH W/LG AMTS OF WATER FOR AT LST 15 MIN, LIFTING LIDS
OCCAS; GET PROMPT MED ATTN. SKIN:WASH THORO W/SOAP & WATER, REMOVE
CONTAM CLTHG PROMPTLY & WASH BEFORE REUSE. INGEST:DO NOT INDUCE
VOMIT! KEEP PERSON WARM, QUIET & GET MED ATTN.ASPIR OF MATL INTO
LUNGS DUE TO VOMIT CAN CAUSE CHEM PNEUM WHICH CAN BE FATAL.
INHAL:MOVE TO FRESH AIR. IF BRTHG IS DFCLT, ADMIN OXYG. IF BRTHG
HAS (SUPP DATA)

Flash Point Method:TOC
Flash Point:315F,157C
Lower Limits:0.50%
Upper Limits:8.00%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG. USE
WATER FOR COOLING MATERIAL STORED IN VICINITY OF FIRE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.

Spill Release Procedures:SMALL SPILL:SCRAPE UP/SOAK UP WITH ABSORBENT
MATERIAL. LARGE SPILL:SCRAPE UP/SOAK UP WITH ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:AVOID CONTACT WITH EYES OR SKIN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:IF TLV OF PROD IS EXCEEDED, NIOSH APPRVD AIR
SUPP RESP IS ADVISED IN ABSENCE OF PROPER ENVIRON CTL. OSHA REGS
ALSO PERMIT OTHER NIOSH APPRVD RESPS UNDER SPECIFIED CNDTNS. (SEE
YOUR SFTY EQUIP SUPP). E NGINEERING/ADMIN CTLS SHOULD BE (SUPDAT)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves:WEAR RESIST GLOVES SUCH AS:NITRILE RUB.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN:1994:ANTICIPATED TO BE CARCINOGEN. ANIMAL:LUNG. FIRST
AID PROC:STOPPED, GIVE ARTIFICIAL RESPIRATION. KEEP PERSON WARM,
QUIET AND GET MEDICAL ATTENTION. RESPIRATORY PROTECTION:IMPLEMEN
TED TO REDUCE EXPOSURE.

Boiling Pt:B.P. Text:640F,338C
Vapor Pres:0
Vapor Density:NON VOLAT
Spec Gravity:1.45438
Evaporation Rate & Reference:SLOWER THAN N-BUAC
Appearance and Odor:CREAM COLORED PASTE.
Percent Volatiles by Volume:0

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS, ACIDS, AMINES AND BASES.
Stability Condition to Avoid:KEEP AWAY FROM HEAT AND OPEN FLAME.
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE AND DIOXIDE;
VARIOUS HYDROCARBONS, ETC.

Waste Disposal Methods:SMALL SPILL:INCINERATE OR LANDFILL IN ACCORDANCE
WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS. LARGE
SPILL:INCINERATE OR LANDFILL IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.